超级彩票助手

純鋁酸鈣水泥和磷酸鹽結合劑在耐火材料的使用方法

Author: Admin View: Post Time: 2018 / 08 / 16

純鋁酸鈣水泥和磷酸鹽結合劑在耐火材料的使用方法

 配料順序一般為,1、水→磷酸液→高鋁粉,2、高鋁粉(或是煅燒氧化鋁)→水→磷酸液

    KUNLIAO。HUANJINGWENDU20℃YISHANG,SHUIWEN30℃YISHANGTIAOJIANSHI,JING24~36hKUNLIAO,NIJIANGKEDABIAOZHUNYAOQIU。KUNLIAODEMUDESHI,SHISUANXINGJIEHEJIYUHUNHELIAOZHONGHANYOUDEJINSHUTIEHUOHANTIEHUAHEWUFANYINGFANGCHUQINGQIHOUSHIYONG,BIMIANSHIYONGZHONGCHANSHENGGUZHANG。JIAOBAN。ZUICHU2h,YAOJINGCHANGJIAOBAN,YIHOUMEIGE1XIAOSHIJIAOBAN1CI,MEICIJIAOBAN15FENZHONG,BAOCUNWENDU15℃YISHANG。

超级彩票助手    ZHULUFA,FENHUOJIANGFA、JINIFAHEXIULUFA。HUOJIANGFA,YONGYUQIZHULUDI。FENWUBUCAOZUO,

1、WENHUO,YONGLIANGSHOUZHUAZHUCHANGZHUANLIANGDUANCEMIANGUJIANG,XIANXIAOMIANHOUDAMIAN,DAIJIANGMANHOUQINGXIEQUCHU,SHINIJIANGXIANGYICELIUDONG,KAOQIQIAN,SHIZHUANDIAOXIANG,NIJIANGXIANGXIANGFANFANGXIANGLIUDONG,RANHOUBAZHUANDIKAOJIEQI;

2、DIKAO,BAGUMANNIJIANGDEZHUANYAOJINKAOZAIYIQIHAODEDIYIPAIZHUANDEXIABU,YIBANYI30~50mWEIYI,RUKAODEGUOGAOSHI,HUIYOUYULADONGSHI,BAXIABUNIJIANGJICHU,RONGYIZAOCHENGXIABUKONGJIANGXIANXIANG;

3、DUANLA,JIZHUANDIKAOHOUSHANGXIALADONGDEJULIYAOXIAO,YIBANZAI20~40m,LADONGJULIGUODA,HUIBAXIABUNIJIANGJICHU,CHUXIANNIJIANGBUMAN,CHENGHUALIAN;

超级彩票助手4、ZHONGCAI,JIZAICAIQISHI,YAOYONGLIZUOYONGZAIZHUANDEXIABU,YIBAOCHIZHUANDECHUIZHIDU;

超级彩票助手5、MANLI,JIZAIZHONGCAIHOU,YAOFUCHIZHUZHUANMANLISHOU,YIPOSHAOZHUANZHANGZUIHENIJIANGLIUSHIXIANXIANGDEFASHENG。

超级彩票助手    JINIFA,ZHUYAOYONGYUQIZHULUQIANG。JIANGNIJIANGPUPINGHOU,YONGZHUANCEMIANGUJIANG,HUOCAIYONGXIANYANCHANGMIANDUANLAZHONGROUJICHUNIHOU,ZAITUIJIDUANMIANCHUJIANG。YOUYUNIXIACHENLIUDONG,BUYICAIYONGSUIQISUIGUAJIANGDEQIZHUFANGFA,YIBANYINGZAIQIZHU5~6KUAIZHUANHOUZAIXINGGUAJIANGGOUFENG。

超级彩票助手    XIULUFA,XIULIEFENGYUHUOZHUAN,YONGCHOUDUSHIYIDENIJIANGFENCENGTIANSHIYAGUANG,LIEFENGCHAOGUO30mSHI,KEPEIRU2~3mmDEGAOLVKELI,ZHANSHULIAOFENDE30%ZUOYOU,KUNLIAOHOUYONG。

    SHAOSUNCHENFA,JUBUSUNHUAI。BASHAOCHUANCHULUPIBOKAI,ZAIWAIMIANLUPISHANGHANSHANGXINLUBAN,SHANGLIUGUANJIANGKOU,DAIGUANMANJIANGHOUHANSHI,HUOZAISUNHUAICHUMOSHINIJIANGHOUTOURUSHIYONG。

    密封爐墻,主要采用機具噴襯法和人工刷漿法,噴補高爐內襯,泥漿要稠,噴補層要厚,如熱噴焦爐碳化室,泥漿要稀,厚度1~2m。熱噴溫度800℃以下噴補為宜:人工刷漿,多用于小面積密封墻,優點掛漿均
超级彩票助手 勻,少流失。施工完后,即時烘爐,一般烘至500℃即可。

    涂料修補料,涂料施工最好熱修補(100-200℃),涂料涂抹在澆注料上,用手錘敲平,厚50m為宜。研制了一種新型磷酸鹽結合噴補料,其主要組成:高鋁骨料(A1O386.54%)70%,高錐細粉15%,a-氧化鋁微粉15%,結合劑固體磷酸二氫鋁5.5-7.5%,SiO2微粉3.5%,礬土水泥2.5%,抑制劑NHI-660.12%。噴補料的施工采用半干法噴補,將分裝好的料倒入運轉的攪拌機內,按比例加入磷酸鹽結合劑,磯土水泥,NH-66后,混練3分鐘,緩慢加入2.5%的水,混練均勻后出料,然后立即放入噴補設備的罐體內,關閉罐體閥門,開啟風壓2-3MPa,將水位調整到合適的位置,開啟送料閥門,進行噴補。

SHIYANJIEGUORUXIA:

1、KESHIGONGSHIJIANHEYINGHUASHIJIANSUIJIEHEJIJIARULIANGZENGJIAERYANCHANG。LINSUANLVRONGYENONGDU40%,JIARULIANG12%,CHUNLVSUANGAISHUINI8-9%JIARUKESHIGONGSHIJIAN3FENBANZHONG,YINGHUASHIJIAN9FENBANZHONG。

超级彩票助手2、KANGBAOLIEXING。SHIYANG(60mrZHENGFANGTI)25℃YANGHUHOUBUJINGGANZAOZHIJIEFANGRU800℃CHE1000℃CLUZHONGJIARE,JIARE10minsHOUGUANCHABAOLIEQINGKUANG。DANGLINSUANYANNONGDUCHAOGUO30%DESHIYANGMEIYOUFASHENGBAOLIE。LINSUANYANHANLIANGJIAOSHAODESHIYANGZAIGANZAOGUOCHENGZHONGLINSUANYANQIANYIDAOSHIYANGBIAOMIAN,XINGCHENGLEYICENGZUZHISHUIZHENGQIZHENGFADEMO,YINCIRONGYIBAOLIE。

3、KANGBOLUOXING。No4SHIYANGZAI1200℃JINGSHUILENGHEFENGLENG10CIXUNHUANHOU,SHIYANGNEIBUZHIYOULIEWENCHANSHENGERMEIYOUBOLUOFASHENG。

4、粘結強度,將1500℃燒后的純鋁酸鈣水泥超级彩票助手低水泥澆注料與磷酸鹽結合的修補料制成40×40×160m的試樣,經110℃,1000℃,1300℃和1500℃處理后的CMOR(粘結強度)分別為1MPa,2.6MPa,3.8MPa和4.6MPa。試樣經在水泥回轉窯的出口、入口和預熱器使用一年以及焚燒爐側壁使用一年效果很好,無爆裂和磨損現象。

 

 


上一篇:電熔純鋁酸鈣水泥在耐火材料中的發展和應用

下一篇:鐵鉤耐火澆注料用純鋁酸鈣水泥

© 2018 河南豐潤冶金材料有限公司 版權所有
上海天天彩选4 黑龙江快乐十分 甘肃11选5 黑龙江快乐十分 河南11选5 河南11选5 湖南快乐十分 甘肃11选5